Fuji Mac 80R2 (Hiblow 80 replacement)

I have two fish ponds and many tubs/aquariums. The large pond is about 15,000 - 18,000 gallons so I have some experience with large air pumps. Over the years, I have used many types/brands of air pumps ranging from the loud and hot "commercial" air pumps, linear diaphragm air pumps (Chinese, Taiwanese, Japanese, with increasing quality in that order), to the linear piston air pumps (mainly Medo brand). I can say that Fujimac is one of the best pumps in terms of efficiency and noise level at the rated air pressure and volume. The only thing unknown at this point is diaphragm and flapper valve longevity. However, from my past experience with Japanese made diaphragm pumps, I think the Fujimac should offer industry leading service life for the rubber parts. From what I have read, the Hiblow XP-80 pump is in the same league as the Fujimac 80. They both use strong rare earth magnets thus having higher efficiency. However I have no first-hand experience with the XP-80 pump. The (Fujimac) pump is nominally rated at 51 Watts. In my installation, it consumes only about 38 Watts (see photo). I used a Kill-A-Watt meter to measure power consumption when the pump is running through about 25 feet of 5/8" ID tubing to a large EPDM 20" long cylindrical membrane diffuser wrapped around 2" PVC pipe. The water depth is about 4.5 feet deep. A typical 80 LPM air pump uses, on average, 60-70 watts. The other photo showing three air pumps driving three EPDM diffusers and you can see the FujiMac put out slightly more air (hard to see in photo) at almost half the electricity consumption. Around the year 2000, I acquired a couple Gast (USA company) "industrial" linear diaphragm air pumps but the pumps were made in Japan. I do not know which Japanese company OEMed these Gast pumps but the first one ran for 15 years straight 24/7 and finally one of the two diaphragms was torn. The replacement has been running since year 2015 non-stop up to today. I hope the Fujimac air pumps will run that long as well. On YouTube, there are a few videos about the Fujimac air pumps, some produced by Wholesale Septic Supply and others made by Fujimac (the company). In one of the videos, a Fujimac service person made this written comment: ". . . typically go more than ten years on the original diaphragms". I understand rubber parts longevity depends on climate and application setup, but I certainly hope this will be the case in my cool Michigan climate and good tubing/diffuser setup at reasonable water depth. I really like this pump and I ordered another one yesterday.

I've had it running for nearly a year trouble free. Easy to install

I bought this to replace a Blue Diamond unit of the same size. I always had it in a cement block bunker with dirt for noise suppression. It's located 60 feet from the house. Even with the windows closed, I could always hear it humming outside. This Fuji is super quiet. I can feel the vibration while standing next to it, but that's it. Ten feet away and I can't even tell it's there. I can see that it's putting out the same amount of air with none of the noise. I love this Fuji aerator.

I used to work for a septic service company that sold the Fuji Mac aeration pumps for all new aerobic system installations as well as replacements for older pumps that could no longer be rebuilt. I inspected and installed a lot of these pumps and learned that they were rugged, long lasting pumps that required very little maintenance to keep them running long and strong. My home pump started losing pump pressure recently and I was thrilled that I could purchase this pump from Amazon. It is a quick and easy installation even if you need to use the instructions to get it up and running. Another great thing about this pump in my opinion is the price. It isn’t cheap but it is less than half of the price we charged for a new pump at my former company.

This air pump was suggested by my septic company. Worked perfect, good price and fast shipping.

Shipped fast and was a direct replacement for a different prank pump that didn’t work very well. Only been running two weeks so hopefully it lasts a long time.

Very quiet and vibration free Installed under bedroom and dont notice compared to previous Thomas aerator. Cant report on longevity. Just clamp on outlet hose and plug in. Couldnt be simpler.

This is an excellent pump for aquaponic, pond, septic... It is solidly built, running cool and generous air flow. I bench mark this pump (80lpm) with another pump (100lpm) in 2 & 6 ft deep pond. This FujiMac delivers performance better than the bigger capacity pump in air stone, epdm diaphragm etc... Best price in energy efficient and over all functionality.